Évaluations - 3, GPA: 3.7
(
)
)
|
Facilité d'utilisation
INSTALLATION AND OPERATING INSTRUCTIONS 1.2A Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 4Y8 Canada / 103 Miller Drive, Crittenden, Kentucky, USA, 41030 Phone (705)721-1212 • Fax (705)722-6031 • replaces.com • ask@napoleonproducts.com SAFETY INFORMATION ! WARNING If the information in these instructions are not followed exactly, a fi re or explosion may result causing property damage, personal injury or loss of life. - Do not store or use gasoline or other fl ammable vapors and liquids in the vicinity of this or any other appliance. - WHAT TO DO IF YOU SMELL GAS: • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbour’s phone. Follow the gas supplier’s instructions. • If you cannot reach your gas supplier, call the fi re department. - Installation and service must be performed by a qualifi ed installer, service agency or the supplier. CERTIFIED FOR CANADA AND UNITED STATES USING ANSI/CSA METHODS. CERTIFIED UNDER CANADIAN AND AMERICAN NATIONAL STANDARDS: ANSI Z21.88 • CSA 2.33 FOR VENTED GAS FIREPLACE HEATERS. $10.00 GDS28N & GS28N NATURAL GAS GDS28P & GS28P PROPANE Model GS28 is made up of Model GDS28 and B-Vent Adapter Kit GS-150KT TABLE OF CONTENTS 1.0 INSTALLATION OVERVIEW 3 2.0 INTRODUCTION 4 2.1 DIMENSIONS 5 2.2 GENERAL INSTRUCTIONS 5 2.3 GENERAL INFORMATION 7 2.4 RATING PLATE INFORMATION 8 3.0 VENTING 9 3.1 VENTING LENGTHS AND COMPONENTS 10 3.2 TYPICAL VENT INSTALLATION 11 3.3 SPECIAL VENT INSTALLATIONS 12 3.3.1 PERISCOPE TERMINATION 12 3.4 VENT TERMINAL CLEARANCES 13 3.5 VENTING APPLICATION FLOW CHART 14 3.6 DEFINITIONS 14 3.7 ELBOW VENT LENGTH VALUES 14 3.8 TOP EXIT HORIZONTAL TERMINATION 15 3.9 TOP EXIT VERTICAL TERMINATION 17 3.10 VERTICAL THROUGH EXISTING CHIMNEY 19 4.0 INSTALLATION 20 4.1 MINIMUM CLEARANCES TO COMBUSTIBLES 20 4.2 WALL AND CEILING PROTECTION 21 4.2.1 HORIZONTAL INSTALLATION 21 4.2.2 VERTICAL INSTALLATION 22 4.2.3 HORIZONTAL AIR TERMINAL INSTALLATION - MODEL GDS28 22 4.2.4 VERTICAL AIR TERMINAL INSTALLATION 23 4.3 APPLIANCE VENT CONNECTION 24 4.4 MOBILE HOME INSTALLATION - MODEL GDS28 24 4.5 GAS INSTALLATION 25 4.6 OPTIONAL WALL SWITCH / THERMOSTAT / REMOTE 25 4.7 B-VENT SPECIFICS 26 4.7.1 CHIMNEY INSTALLATION 26 4.7.2 INSTALLING "B" VENT 27 4.7.3 B-VENT 27 4.7.4 COMBUSTION AIR 28 4.7.5 ADDING VENT SECTIONS 28 5.0 FINISHING 29 5.1 DOOR CLOSING AND OPENING 29 5.2 LOG PLACEMENT 30 5.3 GLOWING EMBERS 31 5.4 CHARCOAL EMBERS 31 5.5 LOGO PLACEMENT 31 6.0 OPERATION 32 6.1 OPERATING/LIGHTING INSTRUCTIONS 33 7.0 ADJUSTMENT 34 7.1 PILOT BURNER ADJUSTMENT 34 7.2 VENTURI ADJUSTMENT 34 7.3 FLAME CHARACTERISTICS 35 7.4 RESTRICTING VERTICAL VENTS - MODEL GDS28 35 8.0 MAINTENANCE 36 8.1 CARE OF GLASS 36 8.2 BLOWER REPLACEMENT 37 9.0 REPLACEMENTS 38 10.0 TROUBLE SHOOTING 42 11.0 WARRANTY 45 12.0 SERVICE HISTORY 46 NOTE: Changes, other than editorial, are denoted by a vertical line in the margin. W415-0153 / B / 06.10.10 3 W415-0153 / B / 06.10.10 Door, see “DOOR CLOSING / OPENING” section. Rating plate, see “RATING PLATE” section. Logo, see “LOGO PLACEMENT” section. Vent, see “VENTING” section. 1.0 INSTALLATION OVERVIEW 2.0 INTRODUCTION 3.1A ! WARNING • THIS APPLIANCE IS HOT WHEN OPERATED AND CAN CAUSE SEVERE BURNS IF CONTACTED. • Do not operate appliance before reading and understanding operating instructions. Failure to operate appliance according to operating instructions could cause fire or injury. • Risk of fire or asphyxiation do not operate appliance with fixed glass removed. • Do not connect 110 volts to the control valve. • Risk of burns. The appliance should be turned off and cooled before servicing. • Do not install damaged, incomplete or substitute components. • Risk of cuts and abrasions. Wear protective gloves and safety glasses during installation. Sheet metal edges may be sharp. • Do not burn wood or other materials in this appliance. • Young children should be carefully supervised when they are in the same room as the appliance. Toddlers, young children and others may be susceptible to accidental contact burns. A physical barrier is recommended if there are at risk individuals in the house. To restrict access to an appliance or stove, install an adjustable safety gate to keep toddlers, young children and other at risk individuals out of the room and away from hot surfaces. • Clothing or other flammable material should not be placed on or near the appliance. • Due to high temperatures, the appliance should be located out of traffic and away from furniture and draperies. • Ensure you have incorporated adequate safety measure to protect infants/toddlers from touching hot surfaces. • Even after the appliance is out, the glass and/or screen will remain hot for an extended period of time. • Check with your local hearth specialty dealer for safety screens and hearth guards to protect children from hot surfaces. These screens and guards must be fastened to t...