Évaluations - 1, GPA: 4
(
)
)
|
Facilité d'utilisation
Steam coming out around top covers or sides. Generator Cover’s wingnut is loose. Tighten wingnut. Generator Cover is warped. Replace Generator Cover. 20 P/N 1010699 Rev. M 12/06 MIRACLE STEAMER TROUBLESHOOTING (continued) Problem Possible Cause Corrective Action Unit floods overnight and/or continues to steam even when in idle mode. Solenoid Valve is leaking due to debris trapped inside the plunger (MS-250/255). Attempt to flush the debris out of the valve by rapidly operating the unit on a number of “single shot” cycles and then letting it rest. If the unit still leaks, disassemble the Solenoid Valve and clean out the plunger. Reassemble unit and test. If a leak is still present, replace the Solenoid Valve. Contact your maintenance person or Authorized Service Agency. Solenoid Valve is installed incorrectly (MS-250/255). If the Solenoid Valve was replaced, verify that the “IN” and “OUT” labels on the valve correspond to the water flow. There is no pre-strainer or filter on the water line just before the unit (MS-250/255). Equipment was supplied with a strainer. If missing, install strainer. P/N 1010699 Rev. M 12/06 21 MIRACLE STEAMER 22 P/N 1010699 Rev. M 12/06 REPLACEMENT PARTS .......... .... .... .... .... .... .... .... .... .... .... .. .. .. .... .... .... .... .... .... .... .... .... .... .... .... .... .... .... 89 81 88 81 93 80 85 79 82 83 84 86 87 85 .... .... .. .... .... .... .... MS-150/155/250/255 NOTE: Refer to parts list on page 25. MIRACLE STEAMER P/N 1010699 Rev. M 12/06 23 READY 43 31 32 33 23 55 28 46 72 69 49 67 48 49 71 51 57 55 37 68 19 55 26 59 60 27 43 1 9 39 55 4 49 43 46 2 96 96 96 NOTE: Refer to parts list on page 25. MS-150/155 Service Compartment REPLACEMENT PARTS (continued) MIRACLE STEAMER 24 P/N 1010699 Rev. M 12/06 READY 22 55 READY 72 49 67 48 50 71 51 57 55 68 69 19 55 26 59 60 27 29 32 33 23 55 28 46 30 5 55 46 37 2 97 NOTE: Refer to parts list on page 25. MS-250/255 Service Compartment REPLACEMENT PARTS (continued) MIRACLE STEAMER REPLACEMENT PARTS (continued) MS-150/155/250/255 1 0010159 Filter Assy., Water Tank (MS-150/155) 1 2 7000652 Relay 1 3 0010584 Inlet Hose Assy. w/ strainer 1 (MS-250/255) 4 7000137 Pump/Tube Assy., 24VAC 1 (MS-150/155) 5 4040145 Solenoid Valve 24VAC 1 (MS-250/255) 6 7000237 Top Cover Assy. (Includes #41 & #42) 1 7 0011314 Steam Vent Assy. 1 8 0021131 Floor/Chassis Weldment 1 9 0021179 Access Cover Weldment 1 (MS-150/155) 10 7000246 Generator, 230V 1 7000245 Generator, 208V 1 7000300 Generator, 120V 1 11 0300129 Stud, Cover Hold Down 1 12 040P138* Locknut, 1/2” 1 13 040K251 Strain Relief (includes #12) 1 14 05P2199* Spacer 2 15 0503431 Diffuser, Steam 1 17 0503433 Cover, Generator 1 18 0503434 Cover, End Housing 1 19 0503435 Retainer, Thermocouple 1 20 0503988 Spatula MS-150/250 1 21 0021314 Liner, Cavity (MS-150/250) 1 22 0503441 Access Cover (MS-250/255) 1 23 0503472 Bracket, Hi-Limit Support 1 24 0700452 Power Cord, NEMA 6-20P 1 0700453 Power Cord, CEE 7/7 1 0700463 Power Cord, Nema 5-15P 1 26 100P967 Label, Marking 1 27 1001036 Label, Control Panel 1 1001102 Label, Control Panel (MS-150/250 1 Mfg. # 9100432, 433, 424, & 439) 28 2000203 Tube, Restrictor, 1/4” 1 29 2000207 Tube, Inlet, 1 1/4 x 2-1/2” Long (MS-250/255) 30 2040103 Connector, Male, 1 1/4 x 1/8 NPT (MS-250/255) 31 2040106 Adapter, Tube/Hose (MS-150/155) 1 32 2040145 Elbow, Female, 1/8” x 1/4” 1 33 2040146 Tee, Female, 1/8” x 1/4” 1 35 210K108 Foot, Rubber (4 Pack) 1 36 2100119 Handle, Spatula (MS-150/250 only) 1 37 4050180 Heat Sink 1 39 2100170 Knob, Chrome (MS-150/155) 1 41 2100249 Guard, Knob 1 Item Part No. Description Qty. Item Part No. Description Qty. 42 2100273 Knob 1 43 211P101 Clamp, Hose, 3/8 (MS-150/155) 1 44 211P103 Clamp, Hose, 1/2” (MS-150/155) 1 46 7000449 Generator Tube, Teflon, 4-1/2” Lg. 1 (MS-250/255) 7000446 Generator Tube, Teflon, 3-5/8” 2 (MS-150/155) 48 300P102* Nut, Speed, “U”, #8-32 2 49 304P105* Nut, Hex, KEPS, #4-40, Zinc 4 50 306P101* Nut, Hex, #6-32 2 51 306P105* Screw, Machine, #6-32 x 1/2” 2 52 306P123* Screw, Machine, #6-32 x 7/8” 2 53 306P130* Nut, Hex, KEPS, #6-32 2 54 306P134* Screw, Machine, #6-32 x 3/8 3 55 308P103* Screw, Machine, #8-32 x 1/4” 6 57 308P105* Screw, Machine, #8-32 x 1/2” 4 58 308P120* Screw, Machine, 4 #8-32 x 5/8” (sltrshd) 59 308P124* Screw, Machine, 1 #8-32 x 1/2” (one-way) 60 308P143* Nut, Hex, KEPS, #8-32 2 61 310P136* Screw, Machine, 4 #10-32 x 1-1/4” (splanhd) 62 310P149* Screw, Machine, 2 #10-32 x 7/8” 63 310P149* Screw, Machine, 2 #10-32 x 7/8” (MS-150) 64 325P170* Nut, Wing, 1/4-20 1 65 4010137 Rocker Switch, Power On/Off 250V 1 4010151 Rocker Switch, Power On/Off 120V 1 66 4010166 Switch, Momentary (GREEN) 1 4010190 Switch, Momentary (WHITE) 1 (for Mfg #9100432, 433, 424, & 439) 67 7000319 Transformer, 115-230/24V 1 68 7000135 Thermostat, Hi-Limit 1 69 4050214 Thermocouple, Type-K 1 70 406P107 Cable Tie 3 71 7000136 Terminal Block, 3-Pole 1 72 7000317 Control Board, 1 Temperature/Timer, 24V, 50/60 Hz 74 338P102* ...